Boil-off gas balanced method of cool down for liquefied natural gas tanks at sea

Maksym Kulitsa, David A. Wood

Abstract view|61|times       PDF download|26|times

Abstract


Cooling down the cargo tanks of liquefied natural gas carriers (LNGC) prior to the ships arrival at discharge and loading ports follow various widely adopted operating procedures. The tank cool-down procedures typically followed cannot though be considered as best practice, because they consume considerable boil-off gas while reducing tank temperatures. An alternative tested method, described here, consumes considerably less liquefied natural gas (LNG) during the tank cool-down process, which is beneficial, particularly during the ballast voyages. In certain circumstances, LNGC consume liquid marine fuels so that they are able to preserve enough LNG heel to complete tank cool down at sea to required low temperatures before reloading can be commenced. The novel method devised for cooling down LNGC, particularly those fitted with membrane cargo tanks, at sea prior to arrival at a loading terminal involves much lower LNG heel consumption than conventional methods. The boil-off gas (BOG)-balanced tank-cool-down method applies continuous spraying, at very low rates, of the tanks with LNG extracted from the heel. This procedure enables the ship’s engines to consume all excess BOG without the need to pass some of it as waste for combustion in the gas combustion unit or steam dump. It also ensures that the LNG cargo tanks are maintained at stable and constant pressure and reduces the coolant LNG quantity consumed. The BOG-balanced tank-cool-down is straightforward to implement and monitor, simplifying tank pressure control. Test results demonstrate that tank cool- down rates of 4 to 5 ◦C/per hour can be maintained such that tank temperatures can be reduced from +30 to -130 ◦C within 37 hours. The method could work on LNGC with Moss-type tanks but is likely to be less effective as they are typically fitted with fewer tank spraying nozzles.

Cited as: Kulitsa, M., Wood, D.A. Boil-off gas balanced method of cool down for liquefied natural gas tanks at sea. Advances in Geo-Energy Research, 2020, 4(2): 199-206, doi: 10.26804/ager.2020.02.08.


Keywords


Reducing wastage of BOG; cooling tanks in LNG carriers; fuel efficiency; tank cool-down strategies; continuous slow-rate tank spraying; minimizing LNG heel

Full Text:

PDF

References


Cao, J., Zhang, X., Zou, X. Pressure control of insulation space for liquefied natural gas carrier with nonlinear feedback technique. J. Mar. Sci. Eng. 2018, 6(4): 133.

Choi, J. Development of partial liquefaction system for liquefied natural gas carrier application using exergy analysis. Int. J. Nav. Archit. Ocean Eng. 2018, 10(5): 609-616.

DNV-GL. EU MRV and IMO DCS, 2019.

Dobrota, D., Lali ´c, B., Komar, I. Problem of boil-off in LNG supply chain. Trans. Marit. Sci. 2013, 2(2): 91-100.

Gomski, P., Michalski, R. Problems with determination of evaporation rate and properties of boil-off gas on board LNG carriers. J. Pol. CIMAC 2011, 6(1): 133-140.

Grotle, E.L., Esoy, V. Dynamic modelling of the thermal response enhanced by sloshing in marine LNG fuel tanks. Appl. Therm. Eng. 2018, 135(5): 512-520.

ICS-Shipping. European Union Monitoring, reporting and verification (EU MRV) regulation, 2015.

Kulitsa, M., Wood, D.A. Duality in LNG tank-pressure behaviour and its relevance for ship-to-ship transfers to floating storage and regasification units (FSRU). Adv. Geo-Energy Res. 2020, 4(1): 54-76.

Li, Y., Chen, X., Chein, M.H. Flexible and cost-effective optimization of BOG (boil-off gas) recondensation process at LNG receiving terminals. Chem. Eng. Res. Des. 2012, 90(10): 1500-1505.

MEPC. Guidelines for the development of a ship energy efficiency management plan (SEEMP), 2016.

Migliore, C., Tubilleja, C., Vesovic, V. Weathering prediction model for stored 850 liquefied natural gas (LNG). J. Nat. Gas Sci. Eng. 2015, 26: 570-580.

Mokhatab, S., Mak, J.Y., Valappil, J.V., et al. Handbook of Liquefied Natural Gas. Oxford, UK, Gulf Professional Publishing, 2014.

Pellegrini, L.A., Moioli, S., Brignoli, F., et al. LNG technology: The weathering in above-ground storage tanks. Ind. Eng. Chem. Res. 2014, 53(10): 3931-3937.

Shin, Y., Lee, Y.P. Design of a boil-off natural gas relique-faction control system for LNG carriers. Appl. Energy 2009, 86(1): 37-44.

Wood, D.A., Kulitsa, M. A review: Optimizing performance of floating storage and regasification units (FSRU) by applying advanced LNG tank pressure management strategies. Int. J. Energy Res. 2018a, 42(4): 1391-1418.

Wood, D.A., Kulitsa, M. Weathering/ageing of LNG cargoes during marine transport and processing on FSU and FSRU. J. Energy Resour. Technol. 2018b, 140(10): 102901.


Refbacks

  • There are currently no refbacks.


Copyright (c) 2020 The Author(s)

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

Copyright ©2018. All Rights Reserved