Addressing mobility control challenges in high-pressure high-temperature oil reservoirs via water-saturated CO2 injection
Abstract view|16|times PDF download|2|times Supplements download|1|times
Abstract
The ability of pure CO2 injection into an oil reservoir to bring about CO2 storage is hindered by the fact that CO2 is more mobile than oil. Most "mobility control" methods (such as foam injection) work only at low temperatures. This study investigates whether water-saturated CO2 injection can provide mobility control at high pressures and temperatures. In this study, CO2 and water-saturated CO2 are injected into a Bentheimer sandstone core. Experimental runs are performed at 70 ◦C to simulate a low-temperature reservoir and 116 ◦C to simulate a high-temperature reservoir. The selected pressure ranges from 10.3 to 18.6 MPa. Results show that water-saturated CO2 consistently exhibits lower mobility than pure CO2. Hence, water-saturated CO2 injection provides effective mobility control for both low- and high-temperature reservoirs, especially at higher pressure. The effectiveness of water-saturated CO2 in reducing mobility compared to pure CO2 increases exponentially with pressure. Despite the improved mobility control provided by watersaturated CO2 injection, experimental observation finds net CO2 stored and oil recovery to be similar to that of pure CO2 injection,as CO2 sweep efficiency is already high in experimental runs. However, at field-scale sweep efficiency is low. Therefore, field-scale simulations reveal a 19%-47% increase in net CO2 stored during water-saturated CO2 injection compared to pure CO2 injection.
Document Type: Original article
Cited as: Yin, H., Ge, J., Hussain, F. Addressing mobility control challenges in high-pressure high-temperature oil reservoirs via water-saturated CO2 injection. Advances in Geo-Energy Research, 2025, 16(3): 276-287. https://doi.org/10.46690/ager.2025.06.07
Keywords
References
Abdelaal, A., Gajbhiye, R., Al-Shehri, D. Mixed CO2/N2 foam for eor as a novel solution for supercritical CO2 foam challenges in sandstone reservoirs. ACS Omega, 2020, 5(51): 33140-33150.
Ajoma, E., Saira, Sungkachart, T., et al. Water-saturated CO2 injection to improve oil recovery and CO2 storage. Applied Energy, 2020, 266: 114853.
Ajoma, E., Saira, Sungkachart, T., et al. Effect of miscibility and injection rate on water-saturated CO2 injection. Energy, 2021a, 217: 119391.
Ajoma, E., Sungkachart, T., Saira, et al. A laboratory study of coinjection of water and CO2 to improve oil recovery and CO2 storage: Effect of fraction of CO2 injected. SPE Journal, 2021b, 26(4): 2139-2147.
Arshad, A., Al-Majed, A. A., Menouar, H., et al. Carbon dioxide (CO2) miscible flooding in tight oil reservoirs: A case study. Paper SPE 127616 Presented at the Kuwait International Petroleum Conference and Exhibition, Kuwait City, Kuwait, 14-16 December, 2009.
Bedrikovetsky, P. Mathematical Theory of Oil and Gas Recovery: With Applications to Ex-ussr Oil and Gas Fields. Springer Science & Business Media, 1993.
Bello, A., Ivanova, A., Cheremisin, A. Enhancing N2 and CO2 foam stability by surfactants and nanoparticles at high temperature and various salinities. Journal of Petroleum Science and Engineering, 2022, 215: 110720.
Bloomfield, V. A., Dewan, R. K. Viscosity of liquid mixtures. The Journal of Physical Chemistry, 1971, 75(20): 3113-3119.
Borazjani, S., Behr, A., Genolet, L., et al. Ion-exchange inverse problem for low-salinity coreflooding. Transport in Porous Media, 2019, 128(2): 571-611.
Borazjani, S., Roberts, A. J., Bedrikovetsky, P. Splitting in systems of pdes for two-phase multicomponent flow in porous media. Applied Mathematics Letters, 2016, 53: 25-32.
Cao, C., Liu, H., Hou, Z., et al. A review of CO2 storage in view of safety and cost-effectiveness. Energies, 2020, 13(3): 600.
Chen, H., Wei, B., Zhou, X., et al. Theory and technology of enhanced oil recovery by gas and foam injection in complex reservoirs. Advances in Geo-Energy Research, 2025, 15(3): 181-184.
Chen, Y., Elhag, A. S., Worthen, A. J., et al. High temperature CO2-in-water foams stabilized with cationic quaternary ammonium surfactants. Journal of Chemical & Engineering Data, 2016, 61(8): 2761-2770.
Clark, J. A., Santiso, E. E. Carbon sequestration through CO2 foam-enhanced oil recovery: A green chemistry perspective. Engineering, 2018, 4(3): 336-342.
CMG-WINPROP. Winprop (version 2018). Calgary, Canada: Computer Modelling Group Ltd., 2018.
Dyes, A. B., Caudle, B. H., Erickson, R. A. Oil production after breakthrough as influenced by mobility ratio. Journal of Petroleum Technology, 1954, 6(4): 27-32.
El-Dessouky, E. Appendix A-Thermodynamic properties, in Fundamentals of Salt Water Desalination, edited by Hisham T. El-Dessouky and Hisham M. Ettouney, Elsevier, Amsterdam, pp. 525-563, 2002.
Emrani, A. S., Nasr-El-Din, H. A. An experimental study of nanoparticle-polymer-stabilized CO2 foam. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2017, 524: 17-27.
Ge, J., Saira, Smith, B., et al. Laboratory comparison of tertiary N2, CH4, and CO2 injection into an inland oil field sample. Fuel, 2022, 324: 124635.
Gong, Y., Gu, Y. Miscible CO2 simultaneous water-and-gas (CO2-SWAG) injection in the bakken formation. Paper SPE 175976 Presented at the SPE/CSUR Unconventional Resources Conference, Calgary, Alberta, Canada, 20-22 October, 2015.
Grabowski, A., Nercessian, O., Fayolle, F., et al. Microbial diversity in production waters of a low-temperature biodegraded oil reservoir. FEMS Microbiology Ecology, 2005, 54(3): 427-443.
Gu, Y., Hou, P., Luo, W. Effects of four important factors on the measured minimum miscibility pressure and first-contact miscibility pressure. Journal of Chemical & Engineering Data, 2013, 58(5): 1361-1370.
Habermann, B. The efficiency of miscible displacement as a function of mobility ratio. Transactions of the AIME, 1960, 219(1): 264-272.
Kamali, F., Hussain, F. Field-scale simulation of CO2 enhanced oil recovery and storage through SWAG injection using laboratory estimated relative permeabilities. Journal of Petroleum Science and Engineering, 2017, 156: 396-407.
Kamali, F., Hussain, F., Cinar, Y. A laboratory and numerical simulation study of co-optimizing CO2 storage and CO2 enhanced oil recovery. SPE Journal, 2015, 20(6): 1227-1237.
Kamali, F., Hussain, F., Cinar, Y. An experimental and numerical analysis of water-alternating-gas and simultaneous water-and-gas displacements for carbon dioxide enhanced oil recovery and storage. SPE Journal, 2017, 22(2): 521-538.
Kim, S., Santamarina, J. C. Engineered CO2 injection: The use of surfactants for enhanced sweep efficiency. International Journal of Greenhouse Gas Control, 2014, 20: 324-332.
Kulkarni, M. M., Rao, D. N. Experimental investigation of miscible and immiscible water-alternating-gas (WAG) process performance. Journal of Petroleum Science and Engineering, 2005, 48(1-2): 1-20.
Kumar, N., Sampaio, M. A., Ojha, K., et al. Fundamental aspects, mechanisms and emerging possibilities of CO2 miscible flooding in enhanced oil recovery: A review. Fuel, 2022, 330: 125633.
Kumar, S., Mandal, A. A comprehensive review on chemically enhanced water alternating gas/CO2 (cewag) injection for enhanced oil recovery. Journal of Petroleum Science and Engineering, 2017, 157: 696-715.
Lake, L. W. Enhanced Oil Recovery. Old Tappan, USA, Prentice Hall Inc., 1989.
Liu, M. K., Andrianov, A. I., Rossen, W. R. Sweep efficiency in CO2 foam simulations with oil. Paper SPE 142999 Presented at the SPE EUROPEC/EAGE Annual Conference and Exhibition, Vienna, Austria, 23-26 May, 2011.
Lv, Q., Zhou, T., Luan, Y., et al. A green aqueous foam stabilized by cellulose nanofibrils and camellia saponin for geological CO2 sequestration. Journal of Cleaner Production, 2023, 406: 136980.
Orr, F. M., Jessen, K. An analysis of the vanishing interfacial tension technique for determination of minimum miscibility pressure. Fluid Phase Equilibria, 2007, 255(2): 99-109.
Perera, M. S. A., Gamage, R. P., Rathnaweera, T. D., et al. A review of CO2-enhanced oil recovery with a simulated sensitivity analysis. Energies, 2016, 9(7): 481.
Puerto, M., Hirasaki, G. J., Miller, C. A., et al. Surfactant systems for EOR in high-temperature, high-salinity environments. SPE Journal, 2011, 17(1): 11-19.
Saira, Ajoma, E., Le-Hussain, F. A laboratory investigation of the effect of ethanol-treated carbon dioxide injection on oil recovery and carbon dioxide storage. SPE Journal, 2021a, 26(5): 3119-3135.
Saira, Janna, F., Le-Hussain, F. Effectiveness of modified CO2 injection at improving oil recovery and CO2 storage review and simulations. Energy Reports, 2020a, 6: 1922-1941.
Saira, Yin, H., Le-Hussain, F. Effect of alcohol-treated CO2 on interfacial tension between CO2 and oil, and oil swelling. Advances in Geo-Energy Research, 2021b, 5(4): 407-421.
Saira, S., Yin, H., Le-Hussain, F. Using alcohol-treated CO2 to reduce miscibility pressure during CO2 injection. Paper SPE 202341 Presented at Paper presented at the SPE Asia Pacific Oil & Gas Conference and Exhibition, Virtual, 17-19 November, 2020b.
Schneider, C. A., Rasband, W. S., Eliceiri, K. W. NIH Image to ImageJ: 25 years of image analysis. Nature Methods, 2012, 9(7): 671-675.
Shyeh-Yung, J-G. J. Mechanisms of miscible oil recovery: Effects of pressure on miscible and near-miscible displacements of oil by carbon dioxide. Paper SPE 22651 Presented at the SPE Annual Technical Conference and Exhibition, Dallas, Texas, 6-9 October, 1991.
Thomas, F. B., Holowach, N., Zhou, X., et al. Miscible or near-miscible gas injection, which is better? Paper SPE 27811 Presented at the SPE/DOE Improved Oil Recovery Symposium, Tulsa, Oklahoma, 17-20 April, 1994.
Yin, H., Ge, J., Cook, B., et al. Tertiary oil recovery and CO2 storage from laboratory injection of CO2 or water-saturated CO2 into a sandstone core. International Journal of Coal Geology, 2023, 275: 104300.
Yin, H., Ge, J., Tung, P. K. M., et al. Water-saturated CO2 injection in a carbonate rock-effect of pore heterogeneity. Marine and Petroleum Geology, 2025, 173: 107260.
Zhao, F., Hao, H., Hou, J., et al. CO2 mobility control and sweep efficiency improvement using starch gel or ethylenediamine in ultra-low permeability oil layers with different types of heterogeneity. Journal of Petroleum Science and Engineering, 2015, 133: 52-65.
Zhou, D., Fayers, F. J., Orr, F. M., Jr. Scaling of multiphase flow in simple heterogeneous porous media. Paper SPE 27833 Presented at the SPE/DOE Improved Oil Recovery Symposium, Tulsa, Oklahoma, 17-20 April, 1994.
Zhou, X., Yu, W., Lei, G., et al. Experimental study on dual benefits of improvement of CO2 enhanced oil recovery and its storage capacity for depleted carbonate oil reservoirs. Advances in Geo-Energy Research, 2024, 12(1): 52-65.
Zou, S., Hussain, F., Arns, J., et al. Computation of relative permeability from in-situ imaged fluid distributions at the pore scale. SPE Journal, 2018, 23(3): 737-749.
DOI: https://doi.org/10.46690/ager.2025.06.07
Refbacks
- There are currently no refbacks.
Copyright (c) 2025 The Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.